Product ID:B-100 BUTYL RUBBER SEALANT
MSDS Date:03/21/1991
FSC:8030
NIIN:00N014046
MSDS Number: CFLMS

ADCO PRODUCTS INC

4401 PAGE AVE
MICHIGAN CENTER, MI 49254
US

Emergency Phone: 800-424-9300 (CHEMTREC)

Info Phone: 517-764-0334

Cage: ADC0P

ADCO PRODUCTS INC

457 MICHIGAN CENTER, MI 49254 US

Telephone: 517-764-0334

Cage: ADC0P

STODDARD SOLVENT; (ALIPHATIC HYDROCARBON SOLVENT)

CAS: 8052-41-3

RTECS: WJ8925000

Fraction By Weight: 20%

OSHA PEL 500 PPM

ACGIH TLV: 100 PPM

SILICA, CRYSTALLINE - QUARTZ; (QUARTZ (SIO*2))

CAS: 14808-60-7

RTECS: VV7330000

Fraction By Weight: <1%

OSHA PEL N/K

ACGIH TLV: 0.1 MG/M3 RDUST

TRAINING PROGRAM. ALTHOUGH MFR HAS NO CONTROL OVER

RTECS: 9999999ZZ

NORMAL USE RESPIRABLE QUARTZ CONTAINED IN PROD IS A

RTECS: 9999999ZZ

PRESENT AN INHALATION HAZARD.

RTECS: 9999999ZZ

OF THE WORK DAY. PROD IS READILY REMOVED FROM

RTECS: 9999999ZZ

THOROUGHLY W/SOAP & WATER.

RTECS: 9999999ZZ

& FULL LENGTH FACESHIELD .

RTECS: 9999999ZZ

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:EYE CONTACT:CAN CAUSE SEVERE
IRRITATION, REDNESS, TEARING, BLURRED VISION. SKIN CONTACT:CAN
CAUSE REDNESS, IRRITATION. INHALATION:PROLONGED INHALATION OF
VAPORS MAY CAUSE IRRITATION OF RESPIRATO RY TRACT. INTENTIONAL
MISUSE BE DELIBERATELY CONCENTRATING AND INHALING VAPOR MAY BE
HARMFUL OR FATAL. (EFTS OF OVEREXP)
Explanation of Carcinogenicity:SILICA, CRYSTALLINE QUARTZ:IARC
MONOGRAPHS, VOL 68, 1997:GRP 1. NTP 7TH ANNUAL RPT ON CARCINS,
1994:ANTIC TO BE CARCIN.
Effects of Overexposure:HLTH HAZ:INGESTION:CAN CAUSE GASTROINTESTINAL
IRRITATION, NAUSEA, VOMITING, DIARRHEA. CHRONIC:EXPOSURE TO
RESPIRABLE QUARTZ WILL NOT BE POSSIBLE WITH THIS PRODUCT UNDER
NORMAL CONDITIONS OF USE.
Medical Cond Aggravated by Exposure:PRE-EXISTING EYE, SKIN & PULMONARY
DISORDERS MAY BE AGGRAVATED BY EXPOSURE TO THIS PRODUCT.

First Aid:EYES:FLUSH W/LARGE AMOUNTS OF WATER, FREQUENTLY FLUSHING
UNDER LIDS FOR AT LEAST 15 MINUTES. SEEK MEDICAL ATTENTION.
SKIN:WASH W/SOAP & WATER. GET MEDICAL ATTENTION IF IRRITATION
PERSISTS. INHAL:REMOV E AFFECTED PERSON TO FRESH AIR, GIVE OXYGEN
OR ARTIFICIAL RESPIRATION AS NECESSARY TO ASSIST BREATHING. GET
MEDICAL ATTENTION. INGEST:DO NOT INDUCE VOMITING. GET MEDICAL
ATTENTION.

Flash Point:106F,41C
Lower Limits:0.5%
Upper Limits:6.0%
Extinguishing Media:FOAM, DRY CHEMICAL OR CARBON DIOXIDE. WATER MAY BE
INEFT, BUT WATER SHOULD BE USED TO KEEP FIRE EXPOSED CONTAINERS
COOL.
Fire Fighting Procedures:USE NIOSH APPRVD SCBA & FULL PROT EQUIP .
TREAT AS CLASS "B" FIRE. LIMIT FIRE FIGHTING TO THOSE TRAINED TO DO
SO. IF LEAK/SPILL HAS IGNITED, USE (SUPDAT)
Unusual Fire/Explosion Hazard:VAPS ARE HVR/AIR & MAY TRAVEL ALONG
GROUND & BE IGNITED BY IGNIT SOURCES DIST FROM HNDLG POINT. RESIDUE
IN "EMPTY" CNTNRS MAY BE EXPLO IF EXPOS TO IGNIT(SUPDAT)

Spill Release Procedures:ELIM ALL IGNIT SOURCES. CONTROL SOURCE OF
SPILL IF IT IS SAFE TO DO SO. VENT ENCLSD AREAS TO PREVENT VAP
ACCUM. RESTRICT ACCESS BY UNAUTHORIZED PERS. ABSORB SPILLED PROD
W/VERMICULITE OR OTHER ABSORB MATL. SHOVEL/SCOOP INTO SEALABLE
CNTNR FOR DISP.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:DO NOT STORE/HANDLE NEAR IGNIT SOURCE.
KEEP CNTNRS CLSD. EFFECTIVELY GROUND PROD TRANSFER SYS TO PVNT
FIRE/EXPLO FROM STATIC DISCHARGE. MIN BRTHG VAP.
Other Precautions:COMBUSTIBLE LIQUID. EMPTY CNTNRS MAY CONTAIN RESIDUAL
PROD. DO NOT REUSE CNTNRS UNLESS PROPERLY RECONDITIONED. AVOID
PRLNG/RPTD CONT W/SKIN. CAUT:IRRIT/MINOR REVERSIBLE INJURY POSS.
MATL MUST BE MODER ATELY HEATED BEFORE IGNIT WILL OCCUR.

Respiratory Protection:FOR LG SPILLS/ENTRY INTO ENCLSD SM SPACES
W/INADEQ VENT, A NIOSH APPRVD PRESS DEMAND SCBA IS REC. IF
ENGINEERING/ADMIN CONTROLS ARE NOT ADEQ TO MAINTAIN SOLV TLV BELOW
REC LEVELS, AN APPROP NIOSH APPR VD RESP SHOULD BE USED IN (SUPP
DATA)
Ventilation:GENERAL EXHAUST AS NEEDED TO KEEP TLV BELOW RECOMMENDED
LEVELS IF ENGINEERING/ADMINISTRATIVE CONTROLS ARE NOT ADEQUATE.
Protective Gloves:BUNA-N GLOVES.
Eye Protection:ANSI APPROVED CHEM WORKERS GOGGS (ING 8)
Other Protective Equipment:ANSI APPROVED EYE WASH FOUNTAIN & DELUGE
SHOWER . TO PVNT RPTD/PRLNG SKIN CONT, WEAR IMPERVIOUS CLTHG &
(SUPDAT)
Work Hygienic Practices:REMOVE CONTAM CLTHG & LAUNDER BEFORE REUSE.
CLEANSE SKIN THORO AFTER CONT, BEFORE WORK BREAKS & MEALS & AT END
(ING 6)
Supplemental Safety and Health
FIRE FIGHT PROC:WATER SPRAY TO DISPERSE VAPS & TO PROT MEN ATTEMPTING
TO STOP LEAK. MIN BRTHG GASES, VAP, FUMES/DECOMP PRODS. EXPLO
HAZ:SOURCE. TO PVNT FIRE/EXPLO FROM STATIC ACCUM & DISCHARGE,
EFFECT IVELY GROUND PROD TRANSFER SYS. OTHER PROT EQUIP:BOOTS IF
CONT IS LIKELY. RESP PROT:CONJUNCTION W/RESP USE & FIT (ING 3)

Boiling Pt:B.P. Text:352F,178C
Vapor Pres:5 @ 78F
Vapor Density:5
Spec Gravity:1.25 (H*2O=1)
Evaporation Rate & Reference:70 (ETHYL ETHER=1)
Solubility in Water:0.5%
Appearance and Odor:PASTE AVAILABLE IN VARIOUS COLORS W/CHARACTERISTIC
ALIPHATIC HYDROCARBON ODOR.
Percent Volatiles by Volume:20 MAX

Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:IN EVENT OF PARTIAL COMBUSTION, FUMES,
SMOKE, CARBON MONOXIDE, ALDEHYDES & OTHER DECOMPOSITION PRODUCTS
MAY BE RELEASED.

Waste Disposal Methods:IF THIS PROD BECOMES A WASTE, IT IS CONSIDERED
HAZ WASTE DUE TO ITS IGNITABILITY. DISP OF I/A/W LOC, STATE & FED
ENVIRON & WASTE REGS. IF THIS PROD BECOMES A WASTE, IT MEETS
CRITERIA OF A HAZ WASTE AS DEFINED UNDER RCRA
(40CFR261):IGNITABILITY.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.